comparison of quarydust as fine aggregate

Study on Performance of Quarry Dust as Fine Aggregate in ...

2018-3-7  The suitability of quarry dust as alternative material for the river sand in concrete manufacturing is studied. M25 grade concrete was prepared with 0%, 20%,

More

The Utilization of Quarry Dust as Fine Aggregates in

The Utilization of Quarry Dust as Fine Aggregates in Concrete Vishal Agrawal1, Pankil Shah1, ... function of the fine aggregate is to assist in producing workability and uniformity in the mixture. ... To determine the significant properties of quarry dust and compare it with the properties of conventional sand.

More

Use of Quarry Dust as fine aggregates by Partial ...

2017-7-15  1. Replacement of fine aggregate by quarry dust at partial replace results the increase in strength of concrete. 2. The concept of replacement of natural fine aggregate (sand) by quarry dust may help in many ways such as it is helpful to control environment pollution, erosion of river bank might stop and also the waste quarry material can be

More

High Performance Concrete using Quarry dust as Fine

2016-2-29  ABSTRACT² This paper describes the experimental study of High-Performance concrete with quarry dust as fine aggregate in addition of steel fibre. To over-come the difficulties due to excessive sand mining, quarry dust was used as fine aggregate. Quarry dust

More

Comparing the Compressive Strengths of Concrete Made

Table 10 . Comparison of the compressive strength of concret e made with quarry dust and that made with river sand as fine aggregate after 28 days curing (Q = quarry dust, S = river sand) . S/N Mix ratios Water content Cube strength, Q (N/mm 2) Water content Cube strength S (N/mm 2) 1 0.45:1:1:2.5 0.45 21.00 0.52 15. 09

More

Study on Partial Replacement of Fine Aggregate by

2019-7-1  replacement of fine aggregate replacements varies as 0,25,50,75% of riversand. The study explains that quarry dust has required properties of fine aggregate and 50% of quarry dust can be replaced in sand to produce optimum strength of concrete. 25% replacement of quarrydust with fine aggregate gives same strength values as control mix

More

high performance concrete using quarry dust as fine

2014-6-1  To over-come the difficulties due to excessive sand mining, quarry dust was used as fine aggregate. Quarry dust is the fine material, produced from gravel crushers. Super plasticizers were used to improve workability of concrete. Cement was replaced

More

Feasibility of Quarry Dust to Replace River Sand as Fine ...

In this study the properties of concrete with quarry dust as fine aggregate is studied to find out its suitability to replace river sand in structural concrete. Furthermore, use of fly ash with 30 ...

More

Effect of Replacement of Natural Sand by M-Sand as Fine ...

2015-1-1  quarry dust shows good strength and durability.[2] Based on experimental investigation, it is found as an alternative material to the natural river sand. The physical and chemical properties of quarry dust satisfy the requirements of fine aggregate. It is found that quarry dust improves its

More

COMPARATIVE ANALYSIS OF RIVER SAND, M-SAND

2019-5-10  The fine aggregate distribution of the examination or particle size demonstrates that it is near evaluating zone II or IS:383-1970. 3.3.1 RIVER SAND (RS) The natural fine aggregate is the river sand which is the most commonly utilized natural material for the fine aggregates that is utilized, but the recent social factors that

More

High Performance Concrete using Quarry dust as Fine

2016-2-29  ABSTRACT² This paper describes the experimental study of High-Performance concrete with quarry dust as fine aggregate in addition of steel fibre. To over-come the difficulties due to excessive sand mining, quarry dust was used as fine aggregate. Quarry dust

More

Comparing the Compressive Strengths of Concrete Made

Table 10 . Comparison of the compressive strength of concret e made with quarry dust and that made with river sand as fine aggregate after 28 days curing (Q = quarry dust, S = river sand) . S/N Mix ratios Water content Cube strength, Q (N/mm 2) Water content Cube strength S (N/mm 2) 1 0.45:1:1:2.5 0.45 21.00 0.52 15. 09

More

Study on Partial Replacement of Fine Aggregate by

2019-7-1  replacement of fine aggregate replacements varies as 0,25,50,75% of riversand. The study explains that quarry dust has required properties of fine aggregate and 50% of quarry dust can be replaced in sand to produce optimum strength of concrete. 25% replacement of quarrydust with fine aggregate gives same strength values as control mix

More

high performance concrete using quarry dust as fine

2014-6-1  To over-come the difficulties due to excessive sand mining, quarry dust was used as fine aggregate. Quarry dust is the fine material, produced from gravel crushers. Super plasticizers were used to improve workability of concrete. Cement was replaced

More

COMPARING THE COMPRESSIVE STRENGTHS OF

2018-9-14  Key word: Quarry dust, river sand, compressive strength, water cement ratio, workability. 1. INTRODUCTION Concrete is a mixture of water, cement or binder and aggregates (fine and coarse aggregate) and is a commonly used material for construction (Barritt, 1984). River sand has been the most popularly used fine aggregate in the production

More

Effect of Replacement of Natural Sand by M-Sand as Fine ...

2015-1-1  quarry dust shows good strength and durability.[2] Based on experimental investigation, it is found as an alternative material to the natural river sand. The physical and chemical properties of quarry dust satisfy the requirements of fine aggregate. It is found that quarry dust improves its

More

Study on Compressive Strength of Quarry Dust as Fine ...

2016-7-28  The concept of replacement of natural fine aggregate by quarry dust which is highlighted in the study could boost the consumption of quarry dust generated from quarries. By replacement of quarry dust, the requirement of land fill area can be reduced and can also solve the problem of natural sand scarcity. The availability of sand at low cost as a fine aggregate in concrete is not suitable and ...

More

COMPARATIVE ANALYSIS OF RIVER SAND, M-SAND

2019-5-10  The fine aggregate distribution of the examination or particle size demonstrates that it is near evaluating zone II or IS:383-1970. 3.3.1 RIVER SAND (RS) The natural fine aggregate is the river sand which is the most commonly utilized natural material for the fine aggregates that is utilized, but the recent social factors that

More

Disqussion COMPARATIVE ANALYSIS OF STRENGTH OF

The two fine aggregates; sharp sand and quarry dust were obtained from bed of Unwana river and Amasiri quarry site respectively. Mix design used was 1:2:4 and 0.6 water cement ratio. The results obtained showed that the compressive strength for sand both for 7 and 28 days were 19.78N/mm 2 and 30.25N/mm 2 and were higher than that of stonedust ...

More

Feasibility of Quarry Dust to Replace River Sand as Fine ...

quarry dust can be effectively used to replace sand and fly ash can improve the performance of concrete with quarry dust as fine aggregate. Keywords: Concrete, Fine aggregate, Quarry dust, River sand, Compressive strength, Shrinkage, Workability. 1. Introduction Concrete is one

More

Comparing the Compressive Strengths of Concrete Made

Table 10 . Comparison of the compressive strength of concret e made with quarry dust and that made with river sand as fine aggregate after 28 days curing (Q = quarry dust, S = river sand) . S/N Mix ratios Water content Cube strength, Q (N/mm 2) Water content Cube strength S (N/mm 2) 1 0.45:1:1:2.5 0.45 21.00 0.52 15. 09

More

Study on Partial Replacement of Fine Aggregate by

2019-7-1  replacement of fine aggregate replacements varies as 0,25,50,75% of riversand. The study explains that quarry dust has required properties of fine aggregate and 50% of quarry dust can be replaced in sand to produce optimum strength of concrete. 25% replacement of quarrydust with fine aggregate gives same strength values as control mix

More

high performance concrete using quarry dust as fine

2014-6-1  To over-come the difficulties due to excessive sand mining, quarry dust was used as fine aggregate. Quarry dust is the fine material, produced from gravel crushers. Super plasticizers were used to improve workability of concrete. Cement was replaced

More

An Experimental Study on Quarry Dust as a Fine

2019-4-11  An Experimental Study on Quarry Dust as a Fine Aggregate for Making a Concrete. D. Sathyapriya 1, G. Alagar Raja 2, K. Raguram 3, S. Elayabarathi 4, M. Arunkumar 5 Asst professor 1Dept of Civil Engineering, Sri Rangathar Institute of Engg and Tech, Coimbatore, Tamilnadu. UG Student 2,3,4,5 Dept of Civil Engineering, Sri Rangathar Institute of Engg and Tech, Coimbatore, Tamilnadu.

More

High Performance Concrete using Quarry dust as Fine

2016-2-29  ABSTRACT² This paper describes the experimental study of High-Performance concrete with quarry dust as fine aggregate in addition of steel fibre. To over-come the difficulties due to excessive sand mining, quarry dust was used as fine aggregate. Quarry dust

More

Comparing The Compressive And Flexural Strength Of ...

2017-8-24  The study shall provide an in-depth appraisal on the use of quarry dust as an alternative to the use of river sand for the production of concrete. 1.6 Scope of the Study. The study focuses on the appraisal of the comparison of the compressive and flexural strength of concrete made with river sand and quarry dust as fine aggregate

More

(PDF) Use of Quarry Fine as Partial Replacement of ...

Curing is done strictly as per the Concrete with quarry dust as fine aggregate In a specification of IS 156 : 1959, curing is done at the study in Thailand by Khamput [11] on the compressive room temperature in curing tank filled with normal strength of concrete using quarry dust as fine aggregate and clean water. mixing with admixture type E ...

More

Effects of different industrial waste materials as partial ...

2021-3-1  The grading curves of all the fine aggregate (river sand, alum sludge, limestone dust and quarry dust) are shown in Fig. 2.The result from the graph shows that fine aggregate and the replacement materials are well-graded having 100% passing the No 4 sieve (5 mm) and fall within the grading limits in compliance with ASTM C33.Among all the find aggregate, alum sludge is finer than other fine ...

More

EFFECT OF REPLACING SHARP SAND WITH STONE DUST

2021-4-19  Concrete is very variable material, having a wide range of strengths and stress-strain curve. Concrete composite material whose basic properties are related to the characteristic of constituent element, especially the aggregate. This research aimed to investigate the effect of replacing sharp sand with stone dust as an alternative to only river sand.

More

[PDF] Comparison of physical and mechanical properties

2018-3-1  Abstract This study compared the physical and mechanical properties of river sand concrete with quarry dust concrete. The constituent materials were batched by weight. The water-cement ratio and mix ratio selected for the experimental investigation were 0.55 and 1:2:4, respectively. The specimens were cured for 7, 14, 21 and 28 days. Slump, density and compressive strength tests were carried out.

More